306 Dturbo Stage 1 tune on car video

this is a quick video i made while tuning a friends 306. this just shows the same as darrenjlobb's video, but to help show how the stage 1 is performed on the car.
kkk turbo allen key is 2.5mm.
lucas max fuel allen key is 4mm.

Category:

Autos & Vehicles

Tags:

• pug
• peugeot
• turbo
• darrenjlobb
• dturbo
• tune
• tuning
• stage
• screw
• boost
• max
• fuel
• pump
• lucas
• diesel

[kingding48]

Hey man just looking there great video is that heat rap you have on your's there and do you think it makes much diff

[nizmo7]

@kingding48 if you do the whole pipe like i did and made a blanket to go under the intercooler so the rising heat from the engine doesnt rise in to the intercooler yeah it make a diffrence. if youve been stood engine running for a while it which is where most of soak would happen it does prevent it.

[neilpritch2010]

Do you need to rock the car in neutral or in gear..?????

[nizmo7]

@neilpritch2010 in gear mate. so that your using the movement off the wheels to rotate the pump.

[nizmo7]

@neilpritch2010 in gear mate

[urbex2007]

All you are doing is sending in too much diesel which results in black smoke. A common mistake made. The only way to use that extra diesel is to make each cylinder bigger. You are decreasing performance and efficiency.

[nizmo7]

@urbex2007 you obiously know fuck all about this. black smoke on a diesel is the result of unburnt diesel. by giving a lucas or bosch pump a tune known as a stage one which is were the fuel amount is increased you are delivering a higher amount of diesel compaired to the orignal lean burn. this will result in more power and has been proven about a million times! the only reason you get black smoke is if you over fuel massively by turning more then 15 degree.

[MattJBaugh]

@icecage001 These don;t have ECU's, they are mechanical fuel pumps hence why you can tune them, rather than being electrical

[daavee03]

I thought the minimal PSI on stock is around 12psi? any less and there could be a problem.

[icecage001]

@Dave424123 that should always work.. but he needs ECU with boost read to get rid of the extra smoke - revs or load won't tell correctly ECU about if the air is comming in etc...

[Dave424123]

@urbex2007 No, the only way to make use of the extra fuel is to increase the amount of air, returning the a/f ratio to 13 ish, Since he is increasing his turbo pressure, that means more air so he has to compensate for this by increasing the amount of fuel.