Manco Minibike Start

This is my Manco Minibike with a 4HP Robin Subaru OHC engine, being started for the first time since last fall.

I only had enough gas to fill up the fuel filter, that's why it ran out after a few minutes. Also, after it was warmed up, it didn't stall once with no choke.

Category:

Entertainment

Tags:

• Manco
• Minibike
• mini
• bike
• HP
• horse
• power
• horsepower
• Robin
• Subaru
• thunder
• bird
• engine
• start
• gas
• gasoline

[Italianmob1517]

hi i talk to u about a year ago because we have the same minibike and i found out the problem with it, now i was just wondering how do you do a oil channge?? i think i found the bolt on the bottom infront of the engine, but what kind of oil do you use?thanks mike

[launboy8]

@Italianmob1517

Yes just unscrew the bolt in the front and it'll drain out. 10w-30 should be fine. It's pretty standard among these types of engines. That's what I run in mine.

As for the chain, I'm not sure what to tell you, moving the engine forward fixed my issue for the most part. Check your side to side alignment of the two sprockets. and your clutch sprocket for wobble. I hope you're not taking it somewhere to get the chain put back on. you can do it yourself in about 30 seconds.

[launboy8]

cont... just get the chain back on the clutch sprocket, and as much as you can on the wheel sprocket before it gets to tight. then just push the bike forward and the chain will pop back on.

[Italianmob1517]

@Italianmob1517 one more thing i been hearin a noise from the clutch and it saids put Oil here? it saids oil clutch or somethign like that, what kind of oil do you use for the clutch? thanks for all the help man

[launboy8]

@Italianmob1517 I just used motor oil. 10w30 I think.

[Italianmob1517]

i have the same minni bike and same engine.Theproblem i have wit it is that the chain pops off and do you have any problem with the cluth?i bought mine two year ago for 650 and i keep havin problems wit it

[launboy8]

Nope, no problems with my clutch yet. The chain will pop off mine occasionally, but it's a rare occurrence. If yours does it often, it's probably loose. Loosen the four engine mounting bolts and slide the engine forward until the chain is tight. Also, for the chain to stay tight you'll probably need two people, one to pull engine, other to tighten bolts. Make sure to tighten the rear two blots first or the chain will end of slack again. Also, make sure it's straight and inline with the chain.

[eviloolive1]

what i did was stick a piece of wood between the engine and frame to gain leverage then had someone's tighten the bolts

[Italianmob1517]

hey i been ridinhg my mini bike but everytime i ride it,the chain comes off and i just got this 3 years ago,And i move the engine up and the chain still comes off, and i spend show much mone y to get this fix all the time,my dad saidas i need a biggger frame

[Italianmob1517]

i already did Dat,yo man is it me on is da bile to low to the Ground anything i hit a stick or something the chain falls off,how is the mini bike in the woods